Gem Car Battery Buyers Guide
Early model GEM Cars use wet cell or flooded type batteries, while the later models switched to GEL type batteries. Gel type of deep cycle batteries will power the GEM Car, but for recharging, the on-board charger must have the correct charging algorithm selected. For GEM Car Charger Replacement Guide
Questions We Get Asked Daily Regarding GEM Car Battery Maintenance and Charging
Q: Which batteries are best for Gem Car?
A: #1 Lithium 72v battery is very best #2 12V Group 30 or 31 deep cycle batteries
Strong, deep cycle batteries. Not wal-mart, Costco or mid-grade marine/RV deep cycle batteries.
Q: Are sealed deep cycle batteries better for Gem Car?
A: The discussion has many opinions but the decision is based upon if you dont mind monthly hydration required by flooded cell batteries. Trojan 30XHS, US31DCXC
Are flooded cell type and will consume water when the batteries are recharged.
Typically, the flooded cell type deep cycle batteries have higher amp hours and lifecycles compared to AGM or Gel deep cycle batteries.
1999-2003 GEM Car OE was flooded cell deep cycle batteries 12V 130 ah
Two batteries in the front hood and four under drivers seat.
2004 and up GEM placed all six batteries are under drivers seat and GEM sourced Deka 8G31 as OE
Sealed Battery Choices: Gel & AGM
A Gel deep cycle battery will cost more and should be 12V Group 31 with 98 ah or higher.
Gel batteries work better in hot climates, Arizona etc
Q: Where is the GEM Car charger located?
Deep Cycle Battery San Diego Stocks Multiple Brands Of Batteries For Gem
GEM Car Battery brands in stock are: BigBattery, US Battery, Trojan Battery, Eternity Battery, Deka Gel Battery and Leoch Gel and AGM batteries.
GEM Car OE flooded battery back in 2000 was the Trojan battery part number 30XHS. It is a flooded 12 volt deep cycle battery with 130Ah of power. We advise replacing the 30XHS with the US Battery part number 31DCXC for the same voltage and power but better results. 2003 to 2011 72 volt GEM Car models were equipped with 12 volt Deka Gel bttery part number 8G31. Six seater GEM Cars use nine 8 volt GEL batteries by Deka part number 8G8VGC. 2015 and newer GEM models are 48 volt systems powered by Leoch DTA6224 battery. This battery is in stock at Deep Cycle Battery San Diego and has a part number of Leoch LDC6-224
Volt Trojan Battery Models Available
Longest Lasting 6 volt Deep Cycle Trojan Battery San Diego for 36 volt Golf Cart, RV, Solar, Marine, Aerial Lift, Floor Scubbers..you name it, it does it
Trojan T-105 225 amp hour 6 Volt Trojan Battery San Diego for Sale $158 ea*
In 1952, Trojan pioneered the first deep-cycle golf car battery. Trojan teamed up with Autoette to design a vehicle for a physically-challenged golfer, enabling him to play the game. This began a legacy of leadership in the electric golf car industry that prevails today. Trojan maroon batteries now power golf cars on over 98% of the USs top golf courses.
For Free Battery Local Delivery
Trojan T-105 6 volt deep cycle battery specs
Rate of Discharge: | |
Amp Hours : | 225 AH at 20 Hour Rate |
Weight: | |
Dimensions | 10 in x 7 in x 10 in |
Cycle Life: | 750 Cycles |
*Price for 6 volt Trojan T-105 Batteries for Sale: $158 ea* with exchange
6 volt battery for 36 volt Golf Cart Trojan Pacer Battery 210 amp hour
Trojan 6 volt Pacer Deep Cycle Battery is manufactured by Trojan as an OEM battery. It is a great value for a Trojan built battery for $115.
Deep Cycle Trojan Battery San Diego 6 Volt 210 Amp Hours Trojan Battery Pacer *Price for 6 volt Trojan Pacer Golf Cart Batteries for Sale: $115 ea * with exchange
Deep Cycle Trojan Battery San Diego 6 Volt 240 Amp Hours Trojan Battery T-125*Price for 6 volt Trojan T-125 Batteries for Sale: $189 ea* with exchange
Don’t Miss: Armed Services Vocational Aptitude Battery
Cookie And Privacy Settings
We may request cookies to be set on your device. We use cookies to let us know when you visit our websites, how you interact with us, to enrich your user experience, and to customize your relationship with our website.
These cookies are strictly necessary to provide you with services available through our website and to use some of its features.
Because these cookies are strictly necessary to deliver the website, you cannot refuse them without impacting how our site functions. You can block or delete them by changing your browser settings and force blocking all cookies on this website.
These cookies collect information that is used either in aggregate form to help us understand how our website is being used or how effective our marketing campaigns are, or to help us customize our website and application for you in order to enhance your experience.
If you do not want that we track your visist to our site you can disable tracking in your browser here:
We also use different external services like Google Webfonts, Google Maps and external Video providers. Since these providers may collect personal data like your IP address we allow you to block them here. Please be aware that this might heavily reduce the functionality and appearance of our site. Changes will take effect once you reload the page.
Google Webfont Settings:
Telecom Agm 12v 150ah Deep Cycle Battery For Solar $135
AGM with Carbon for Solar-Vans-MarineP/N PL+C 190FT LeochHalf the price of a lithium deep cycle3000 cycles to 30% DOD2000 cycles to 50% DOD1.5 hours to recharge from 0-90%12 V 190Ah at 10Hr rate.Can be series to 24v and 48v systems.22″ x 4.92″ x 12.6″ tall127 lbs non spill
P/N PL+C 190FT LeochHalf the price of a lithium deep cycle3000 cycles to 30% DOD2000 cycles to 50% DOD1.5 hours to recharge from 0-90%12 V 190Ah at 10Hr rate.Can be series to 24v and 48v systems.22″ x 4.92″ x 12.6″ tall127 lbs non spillCharge at 57 Amps maxMax Discharge Current 2280A
Recommended Reading: Change Battery Nissan Key Fob
Popular Car Battery Categories
Car batteries are rated in cold cranking amps and cranking amps . Due to the mild climate in San Diego, the cranking amps of a car battery, at 32 degrees F is more relevant to car battery San Diego buyers. Another tip for selecting a battery is to select one with the highest reserve capacity you can afford. Reserve capacity is the number of minutes a battery can maintain a useful voltage under a 25 ampere discharge. The higher the RC minute rating, the greater the car batterys ability to run lights, pumps, inverters, and electronics for a longer period before recharging is necessary. Note, Reserve Capacity is difficult and costly to engineer into a battery and requires higher quality cell materials.
About El Cajon Local Gift Card
The El Cajon Local Gift Card is designed to promote and support local businesses in El Cajon.
Buying a Card that can only be spent at local businesses like Deep Cycle Battery San Diego locks dollars into the area and works to introduce people to businesses they might not have tried before. It’s a win for consumers, small businesses, and the community!
Also Check: Alternative To Lithium Ion Battery
Pros And Cons With Flooded And Gel Gem Car Batteries
The 72 volt GEM is powered by six 12 Volt deep cycle batteries. The early GEM batteries are available in flooded or GEL cell batteries. Later model GEM cars come from Polaris with lithium ion or AGM deep cycle batteries. Only high cycle type AGM batteries can be used. Buyer beware of inexpensive AGM batteries.
- Flooded batteries are less expensive than GEL or Lithium and require monthly maintenance.
- Only AGM batteries by Leoch should be used for later model GEMs!
- GEL cell batteries are maintenance free, have high cycle rate and can discharge deeper than flooded deep cell batteries.
- A flooded GEM Car battery will gas and can cause corrosion on the battery tray and cables, and can leave a mess on your floor. Always use terminal grease or protection spray.
- The GEM Cars on board charger must be set to charge the type of battery that is installed unless you buy a lithium battery kit from DCB that includes a LFP charger.
- It is advised to replace the factory Zivan with the Delta Q charger for better battery results for lead acid.
- We will refer you to Lalo for general repair, algorithm change or any other need your GEM has.
- DCB offers battery reconditioning at your location if your onboard charger will not turn on. Call for details. 448-5323
Gem Car And Ford Think Battery Replacement And Maintenance
GEM Cars and Ford Thinks quickly discharge the battery pack if left off charge for more than ten days. Some on board chargers like the early model Zivan will not maintain the batteries even when left plugged in. Same is true for the OE Ford Think on board charger. For Battery Maintenance Tips read step by step guide posted here.
Also Check: How Many Volts Aa Battery
Selecting The Correct Gem Car Battery
A GEM Car battery is a 12 Volt deep cycle battery that is designed for the deep discharging and recharging cycles that a GEM Car requires. Inexpensive marine batteries from Costco will not survive more than a few months under normal driving conditions. Only a 12 Volt battery group size 30 or 31 with 90 or more amp hours should be used. Battery group sizes 24 and 27 are too small and do not have the capacity to continuously operate the GEM Car.
Frequently Asked Questions :
- Where is Deep Cycle Battery San Diego?
Deep Cycle Battery San Diego is located at: 1985 Friendship Dr Ste H, El Cajon, California 92020.
- Want to book a hotel in California?
We can surely help you find the best one according to your needs. Compare and book now!
- What is the phone number of Deep Cycle Battery San Diego?
You can try to dialing this number: 315-5604 – or find more information on their website: deepcyclebatterystore.com
- What is the opening hours of Deep Cycle Battery San Diego?
Monday: 09:00 – 16:30
- Where are the coordinates of the Deep Cycle Battery San Diego?
Latitude: 32.8248241769 Longitude: -116.982014179
Read Also: Lowe’s Battery Weed Eater
Flooded Type 12 Volt Trojan Battery For 2000 To 2002 Gem Car Part Number 30xhs Deep Cycle Battery
New Trojan 30XHS Battery Price with exchange. 12 Volt 130 amp hour rated: This battery is the first battery used by GEM Car as OE. In our opinion, it is no longer the battery of choice for Gem Car application. * Local Delivery is Available in San Diego . Delivery Also Available to San Clemente, Dana Point, Orange County Area for additional fee
Notes on Trojan 30XHS: We have 25% warranty claims for the 30XHS in Gem Car application. Consistent charging and watering is required for this marine style battery
The Trojan Black OEM Battery is Equivalent to the Trojan T-1260 12 Volt 140 amp hour. Perfect Solution for a More Capacity GEM Car Battery without Breaking the Bank!Flooded Gem Car Battery with 140 amp hours*Price for 12 volt Trojan Black OEM Battery for Gem Car Battery Replacement: Note, it is taller and is more difficult to install.. Additionally, the factory battery hold down hardware will not work. You must make changes to the battery hold down hardware as it as must to keep batteries secure!
Local Gifting Made Easy
We all want to support small businesses but shopping for someone locally can be inconvenient and confusing. Not anymore. With the El Cajon Local Gift Card we have rolled up the power of many gift cards into one convenient solution. You can now give anyone the ultimate local gift with options they will love!
Don’t Miss: How Long To Electric Car Batteries Last
Leoch Battery For Gem Car
Early Model 72 VoltGEM Cars Can Use the LeochDeep Cycle 12 volt Gel Batteries for Replacement and are Highly Rated LPG12-100 Ah GEM Car Battery Replacement Excellent Aftermarket GEM Car GEL Battery Replacement Leoch GEL GEM Car Battery for Sale 12 Volt 100 Amp HoursLPG12-100 amp hour rated: This battery is an aftermarket replacement gel battery for GEM Car and has a history of lasting longer than the OE Gel battery. It is a well made, heavy plate design, deep cycle battery with insert style terminals. Leoch is a billion dollar OE mfg for powersport manufactures. The battery handles make it easy to install.*New Leoch Gel GEM Car Battery for Sale: with core * Local Delivery is Free in San Diego Retail Battery Installation Available Lalo. Delivery Also Available to San Clemente, Dana Point, Orange County Area$3000 Order Qualify for Free Freight in Continental USA
Later Model GEM Cars are Powered by 48 VoltLeochBrand AGM Batteries Free Shipping on $3000 orders. Leoch DTA6224 and LDC6-224 GEM Car Battery Replacement
Gel Gem Car Batteries Have The Highest Cycle Rating
Deka GEM Car Battery Part Number 8G31. The Gel battery is 12V with 98 amp hour is one of the highest cycling lead acid GEL battery for Polaris GEM Car.
OE Battery for GEM CarDeka GEL GEM Car Batteries will come from Polaris with GEM stickers. Six 12 Volt 98 Ah batteries connected in series will create 72 volts but remain at 98Ah.Part number 8G31 is mfg by Deka in Pennsylvania and is 98 amp hour rated: This battery is the factory replacement gel battery for GEM Car. It is a powerful deep cycle battery with centered studs for direct replacement. Deka is mfg by East Penn and made in the USA. The battery handles make it easier to install. Note the factory Dominator label is not included to save you money.*New Deka GEM Car GEL Battery for Sale: with core * Local Delivery is Available in San Diego. Delivery Also Available to San Clemente, Dana Point, Orange County Area for additional fee
Deka 8G8VGC Gel Deep Cycle GEM Car Battery for Six Seater GEM Car 72 volt
GEM Car Six Passenger 8 Volt Battery Price $399 eaUse the Deka Gel chemistry deep cycle battery if your E6 Gem has the OE Delta Q charger onboard. If the charger fails or if you already upgraded to the Ride for Fun or Bullet Proof, we advise using the less expensive but very reliable Leoch AGM chemistry 8 V battery instead.
All Prices are plus tax and with exchange for old batteries.
What is the difference between AGM batteries and Gel batteries?
Absorbed Glass Mat Batteries for GEM Car AGM
Recommended Reading: How To Use Noco Genius 1 Battery Charger
Volt Deep Cycle Battery San Diego
6 volt deep cycle batteries are used for RVs and trailers, golf carts, boats, solar systems and aerial lifts. The 6 volt deep cycle battery is not new and has been around for many years. The 6 volt brands we stock are some of our favorite and have low rates of warranties. Call us if you have questions on which brand to use for your application. You may decide an AGM 6 volt battery is best for you.
Gem Car Lithium Battery Replacement Now Available
Naturally, most GEM car owners want the longest lasting and longest range battery available for their GEM. In some cases, we have heard of GEM owners repurposing Chevy Volt and Nissan Leaf lithium ion batteries for their GEM. It is true that in the comparison of traditional lead acid battery and a lithium battery for less weight, longest range and highest cycle rate, clearly the lithium battery is superior. Replacing heavy lead acid batteries with lithium iron phosphate is now available with drop in replacement batteries. Each 12v battery has a built in BMS for protection and can be connected in series to create 72 volts for GEM car.
Now in stock, lithium battery replacement for lead acid batteries. The BigBattery LFP two battery kit is a safe alternative to power your GEM Car . Each battery is 72V and connected together in parallel. Price for 72V Kit $2869 plus tax, w/ lead acid core. Install Available for $300
Part number 72V FALCN LiFePO4 56Ah 4.2kWh
- Sold with replacement charger
Also Check: 2013 Chevy Volt Battery Replacement
Volt Trojan Battery San Diego
Deep Cycle Trojan Battery San Diego 8 Volt 170 Amp Hours Trojan Battery T-875 *Price for 6 volt Trojan T-875 Batteries for Sale: $150 ea* with exchange
Deep Cycle Trojan Battery San Diego 8 Volt 160 Amp Hours Trojan Battery T-8V BB *Price for 6 volt Trojan T-8V BB Batteries for Sale: $140 ea* with exchange
To 2002 72 Volt Gem Car Battery Replacement
Long Lasting and Very Reliable GEM Car Battery Flooded Lead Acid Deep Cycle Gem Car Battery The US Battery 31DCXC-130 12 Volt 130 ah Gem Car Battery Least Amount of Battery Warranty Claims with Us!12 volt US Battery 31DCXC 130 amp hour GEM Car Deep Cycle Battery for GEM Cars that are equipped with six 12 volt batteries. This model GEM will have four under the seat and two in the hood. The onboard charger is a Zivan.
US Battery 31DCXC 130 amp hour rated 12 volt deep cycle GEM Battery. The US 31 DC XC GEM Car battery and is less expensive than the trojan 30XHS battery and in our opinion, the better choice. *New US Battery 31DCXC GEM Car Battery for Sale Price is with core * Local Delivery is Available in San Diego. Delivery Also Available to San Clemente, Dana Point, Orange County Area for additional fee
The 31DCXC require monthly maintenance and consistent charging.
Recommended Reading: Sam’s Tire And Battery
Factory Equipped From 2003 To 2014 Gem Car Models Deka Gel Is Oe For Polaris Deep Cycle Battery Part Number 8g31 4013692 Battery
72 volt GEM Cars have all six 12v batteries under the seat or truck bed. The six batteries are wired in series and use 2 gauge inter connector cables. The Delta Q onboard charger is set for the Deka 8G31 battery. Battery terminals are stainless steel 3/8 stud. Current Polaris GEM Car battery price for Deka 8G31 * Local Delivery is Available in San Diego. Delivery Also Available to San Clemente, Dana Point, Orange County Area for additional feeDeka GEM OE Car Battery Part Number 4013692. Deka 8G31 is the grey battery with GEM sticker